環氧鐵紅車間底漆的使用方法

《環氧鐵紅車間底漆的使用方法》由會員分享，可在線閱讀，更多相關《環氧鐵紅車間底漆的使用方法（3頁珍藏版）》請在裝配圖網上搜索。

1、 Intended Uses 用途 經拋丸或噴砂后的鋼材作保養底漆，保養期可達3-6個月，也可用鋼結構貯藏底漆使用，是一種常溫固化的車間底漆，干燥快，物理機械性能優良，能和各類底漆配套，由于不含金屬鋅等物質，故能減少焊接產生的氣體危害 Suited for steel shot or grit blasted shop primer with 3-6 months of maintenance period and for steel structure tank as primer as well. Curing at ambient temperature. Quick dry,

2、excellent physical and mechanical properties. It is able to match with all the primer and may reduce harm of gas risen from electro-weding owing to no zinc etc in them Product Information產品簡介

3、 雙組分,鐵紅色 Tw opackages, Iron red Application details 產品數據 Volume Solids 固體份 ≥25% Dry Flm Thickness干膜厚度 25 microns equivalent to 100 microns of wet film 25微米相當于100微米濕膜厚 Theoretical Coverage 理論涂布率 8.7m2 /Kg 8.7平方米/公斤 Practical Coverage 實際涂布率 Allow appropriate loss

4、 允許適量損耗 Storage and Handling 施工詳述 Mix Radio 混合比 A : B=15:6.4(by weight) 甲:乙=15:6.4 Method of Application 施工方法 Airless Spray 無空氣噴涂 Recommended 推薦采用 Brush or Roller 涂刷或輥涂 Recommended 推薦采用 Conwentional Spray 傳統噴

5、涂 Not Recommended 不推薦采用 Thinner 稀釋劑 SC006 Maximum thining:≤5% 最大稀釋量：≤5% SC006 Cleaner 油漆設備清洗劑 SCOO6 Pot Life 使用期 2 5℃:24h

6、 2 5℃約24小時 Storage 貯存期 One year 一年 Drying time 干燥時間 Substrate Temperature底材溫度 Touch Dry 表干 (min） Hard Dry 硬干 (h） Over coating Interval 覆涂間隔 Min最短 Max最長 25℃ 4 0.5 16 hours 小時 3months 3個月 環氧鐵紅車間底漆的使用方法 Storagea

7、nd Handling 貯存與管理 Storage 貯存 Store in cool and dry conditions 貯存于陰涼干燥處 Pack size 包裝規格 A;15Kg in 20 liter container 甲:15公斤裝于20公升容器中 B:6.4Kg in 10 liter container 乙:6.4公斤裝10公升容器中 Flash Point 閃點 5℃

8、 Specific Gravity 比重 Approx1.15Kg/L 大約1.15公斤/公升 Specification and Surface preparation 技術要求及表面處 理 steel surface to be painted should be blaseed to Swedish Standard Sa2.5 or rust-removed manually or with power tool to St3. 鋼材表面：噴砂處理至瑞典標準 S

9、a2.5 級或動力工具除銹至 St3級 Limitations 限制 Recommend coat: Spary one coat with high-pressure airless spray for the purpose of reaching 20-25 microns of dry film thickness. Subsequent coat: Epoxy resin paint, coal-tar epoxy paint, chlorinated rubber paint, alkyd resin paint. Phenolic resin pain

10、t, chlorosulphonated polythylene anticorrosive paint and rlighly chloronated polyeerylene anticorrosive paint etc. 建議涂裝道數：高壓無空氣噴涂一道，干膜厚度達20-25微米 后道配套涂料：環氧樹脂涂料、環氧瀝青涂料、氯化橡膠涂料、醇酸樹脂涂料、酚醛樹脂涂料、氯磺化聚乙烯防腐涂料、高氯化聚乙烯防腐涂料。 Safety Precautions 安全措施 This product should be u

11、sed in painting area by perfessional operators. When painting , please refer to Product Data Sheet and MSDS. Consult our company if consumers could not completely understand the precautions for safety and health when applying this product. This product is a kind of solvent-based paint .Inorder to

12、avoid danger or accident, minimal safety precautions,as follow , should be down . The paint contains volatile solvent and is flammable . So must keep away from sparks and open flames.No smoking at applacation site ,Effective precautions (such as using explosion-proof electrical equipments. No stat

13、ic electricity accumulation or metal collision etc) also should be done so as to avoid producting sparks .Flash point of paint , mentioned above on product Data sheet, is the lowest temperature at which mixture of the volatile materails of paint can ignite or explode with air. Enough ventilation is

14、 necessary at application site. In order to remove any danger of explosion, must keep the ratio of gas to air is less than 10%, the minimum explosive limit in general, Therefore, 200m3 of ventilation quantuty per 1Kg solvent (according to the solvent ) is necessary. Product skin and eyes, and avoid

15、 touching with paints (Recommend to wear working clothes, gloves,eye protection, face masks barrier cream and so on ). Kif paint gets in touch with skin , wass fully with large amount of fresh water and soap or appropriate commercial cleaner. In case of eyes being contaminated, rinse with fresh w

16、ater for 10min at least and give medical treatment immediately. Recommend face guard with ventilation pipe for the sake of no absorption of paint fog and harmful solvent gas, especially in bad ventilation. Handle empty containers with care and do not bring about environmental contamination. NOTICE

17、: If consumers have not taken effective safety precautions(Refer to the specfications), our company will NOTbe responsible for any accident. 本產品由專業人緣在工業場所使用,使用時請參照本說明書及健康安全手冊,如客戶在使用本產品前,未能仔細了解有關產品的健康安全知識,請與本公司聯系. 該涂料為溶劑型涂料,為避免事故或危險發生,應采取最低限度的安全措施如下: 此涂料為易燃物,并含有揮發性易燃溶劑,,故必須遠離火星和明火,嚴禁在作業場所吸煙,并采取

18、有效措施,防止火星產生(如采用防爆電器設備,杜絕靜電積累,避免金屬撞擊等)本產品說明書中所列涂料及溶劑的閃點是引起燃燒的最低溫度. 施工場所應盡量進行通風良好,為消除使用過程中的爆炸隱患,應保證足夠的通風量以維持氣體/空氣比例不超過最低爆炸極限的10%,通常每千克溶劑需要200立方米通風量,(與溶劑種類相關)就能維持最低爆炸極限10%的工作環境. 采取有效措施以防止皮膚和眼睛與涂料接觸(如使用工作服,手套,護目鏡,面罩及涂防護油等)如產品不慎接觸到皮膚,應用溫水及肥皂或適當?shù)墓I(yè)清潔劑徹底清洗,如眼睛受到污染,用清水沖洗至少10分鐘,并立即就醫. 建議佩戴通風面罩以避免吸入漆霧和有害溶劑氣體,尤其在通風不良環境下施工時,細心處理舊漆桶以免污染環境. 責任聲明: 對于未按本公司要求采取有效安全措施兒引起的安全事故,本公司不負任何責任. 來源